Exhaust
Muffler, pipes, catalytic converter, exhaust manifold, heat shields, leaks.
What Owners Say
"relay recall d/t sponaneous combustion"
Anonymous, (2021 Ram 3500 Big Horn 6.7-L 6 Cyl diesel)
Reliability
Overall Reliability
The 2021 3500 is less reliable than other cars from the same model year.
Most Common Trouble Spots
Common Trouble Spot
Common Trouble Spot
Owner Reported Trouble Spots
The Reliability score is based on our latest subscriber survey of 2021 Ram 3500 owners. The owner comments describe problems respondents experienced with this vehicle.
Paint/Trim
Paint (fading, chalking, peeling, or cracking), loose interior or exterior trim or moldings, rust.
What Owners Say
"Hood and rear door paint bubbling up. Aluminum panels likely not prepped properly."
Anonymous, VT (2021 Ram 3500 Laramie 6.7-L 6 Cyl diesel)Suspension/Steering
Shocks or struts, ball joints, tie rods, wheel bearings, alignment, steering linkage (includes rack and pinion), power steering (pumps and hoses, leaks), wheel balance, springs or torsion bars, bushings, electronic or air suspension.
What Owners Say
""Had issues with ball joints two different times, had to change all ball joints and bushings the second time""
Anonymous, SD (2021 Ram 3500 Laramie 6.7-L 6 Cyl diesel)Engine Electrical
Alternator, starter, hybrid battery replacement, hybrid battery related systems, regular battery, battery cables, engine harness, coil, ignition switch, electronic ignition, spark plugs and wires failure, auto stop/start.
What Owners Say
"Recall for engine preheater grid. No replacement parts or service for 3 years. Replaced intake/heater/glowplug with new Banks Monster Intake system to eliminate threat of catastrophic engine damage. Ram warned not to keep vehicle in a garage or near other vehicles and wait for replacement preheat relays. No relays for over 3 years. Now over 3 years old and Ram will NOT warranty engine damage caused by bad relay. These engines now experiencing engine damage from head bolt stretching and head gasket failure, and camshaft bearing failure and pushrod failures."
Anonymous A., MT (2021 Ram 3500 Laramie 6.7-L 6 Cyl diesel)Noises/Leaks
Squeaks, rattles, wind noises, seals and/or weather stripping, air and water leaks.
Engine Major
Engine rebuild or replacement, cylinder head, head gasket, turbocharger or supercharger, timing chain or belt.
Fuel System/Emissions
Sensors (O₂, or oxygen, sensor), emission-control devices (includes EGR), fuel-injection system, fuel gauge/sender, fuel pump, problems filling up the tank.
Electrical Accessories
Cruise control, clock, warning lights, body control module, keyless entry, wiper motor or washer, tire pressure monitor, interior or exterior lights, horn, gauges, 12V power plug, USB ports, alarm or security system, remote engine start, heated or cooled seats, heated steering wheel, headlights, automatic headlights, automatic wipers, wireless charging pad.
In-car Electronics
Infotainment system (audio, GPS, phone), rear entertainment system, backup or other camera/sensors, head-up display.
Transmission Major
Transmission rebuild or replacement, torque converter, premature clutch replacement.
Climate System
AC compressor, blower (fan) motor, condenser, evaporator, heater system, automatic climate system, electrical failure, refrigerant leakage.
Transmission Minor
Gear selector and linkage, transmission computer, transmission sensor or solenoid, clutch adjustment, rough shifting, slipping transmission, leaks.
Engine Minor
Accessory belts and pulleys, engine computer, engine mounts, engine knock or ping, fuel leaks, oil leaks.
Drive System
Driveshaft or axle, CV joint, differential, transfer case, four-wheel-drive/all-wheel-drive components, driveline vibration, electrical failure, traction control, electronic stability control.
Engine Cooling
Radiator, cooling fan, water pump, thermostat, antifreeze leaks, overheating.
Body Hardware
Windows, locks and latches, doors or sliding doors, tailgate, trunk or hatch, mirrors, seat controls (power or manual), seat belts, sunroof, convertible top, glass defect.
Brakes
Premature pad/rotor wear, pulsation or vibration, antilock system, parking brake, master cylinder, calipers, squeaking, brake failure, regenerative braking.
2021 Pickup Trucks Reliability
This Car
0
100
Ram vs. Other New Car Brands Reliability
Overall Reliability Verdict
POTENTIAL TROUBLE SPOTS
Reliability indicates how models have performed in the past, providing the basis for predicting
how the vehicles will hold up in the year ahead. These charts provide the most comprehensive reliability
information available to consumers. Based on information received from our latest subscriber survey for
about 380,000 vehicles, our reliability history charts give
you a rundown on how 2000 through 2025 vehicles are holding up in 20 potential
trouble spots, ranging from the engine, transmission, electric motor, EV charging, and brakes,
to power equipment and the electrical accessories.
Recalls
PROVIDED BY
AIR BAGS, STEERING
Nov 06, 2025
A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Summary:
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
What should you do:
Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.
For more information:
NHTSA CAMPAIGN ID Number:
25V765000
Potential Number of Units Affected:
532
ELECTRICAL SYSTEM
Feb 09, 2023
An electrical short in the relay can result in an engine compartment fire with the ignition on or off, increasing the risk of injury.
Summary:
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 2500, 3500, 3500 Cab Chassis, and 4500, 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the heater grid relay with the ignition on or off.
What should you do:
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the relay, free of charge. This will be a Phased campaign. Phase 1 will include 2023 model year vehicles. FCA US will notify dealers on or about 3/23/2023 and begin notifying owners on or about 4/5/2023. Phase 2 will include 2022 model year vehicles and Phase 3 will include 2021 model year vehicles. FCA US will notify dealers and owners on or about 4/27/2023 for Phase 2 and 5/11/2023 for Phase 3. Interim owner notification letters informing owners of the safety risk were mailed March 28, 2023. Owner notification letters are expected to be mailed April 5, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 13A. This recall is an expansion of and supersedes recall number 21V-798.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
23V060000
Potential Number of Units Affected:
302067
STRUCTURE
Dec 08, 2022
An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.
Summary:
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.
What should you do:
Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
22V904000
Potential Number of Units Affected:
1224078
POWER TRAIN
Nov 10, 2022
Leaking transmission fluid may contact an ignition source within the engine compartment, increasing the risk of a fire.
Summary:
FCA US, LLC (Chrysler) is recalling certain 2020-2023 Ram 2500 and 2020-2022 Ram 3500 vehicles. A build-up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.
What should you do:
Dealers will replace the transmission dipstick and transmission vent assembly, free of charge. Owner notification letters were mailed December 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. Chrysler's number for this recall is ZA3.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
22V835000
Potential Number of Units Affected:
250079
ELECTRONIC STABILITY CONTROL (ESC), SERVICE BRAKES, HYDRAULIC
Mar 10, 2022
An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.
Summary:
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
What should you do:
Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
22V140000
Potential Number of Units Affected:
370437
AIR BAGS
Nov 24, 2021
An air bag that deploys improperly can increase the risk of injury in a crash.
Summary:
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 2500, Ram 3500, and 2021 Ram 1500 Classic pickup trucks. The side air bag inflatable curtain (SABIC) assemblies may have been manufactured with the incorrect amount of compressed gas, which can result in an improper air bag deployment.
What should you do:
Dealers will replace the SABIC assemblies, free of charge. Owner notification letters were mailed January 17, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y99.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
21V925000
Potential Number of Units Affected:
376
ELECTRICAL SYSTEM
Oct 14, 2021
A vehicle fire increases the risk of injury.
Summary:
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 3500, 2500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short in the relay may cause a vehicle fire with the ignition on or off.
What should you do:
Owners are advised to park these vehicles outside of buildings or structures, and not near other vehicles, until the vehicle has been remedied. Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. This recall has been superseded by 23V060.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
21V798000
Potential Number of Units Affected:
131177
WHEELS
May 27, 2021
Wheel separation can cause a vehicle crash.
Summary:
Chrysler (FCA US, LLC) is recalling certain 2012-2021 RAM 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles. Incorrect information in the Service and Owner's Manuals may cause the flanged lug nuts to be over-tightened, which could result in a broken wheel stud and possible wheel separation.
What should you do:
Dealers will update the torque specification in the owner's manual and other published service documents. Dealers will also inspect the vehicle's wheel studs, replacing them if necessary, free of charge. Owner notification letters were mailed on November 30, 2021. Campaign Y36 owner notification letters were mailed on November 30, 2021. Campaign Y26 owner notification letters were mailed on December 1, 2021. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's numbers for this recall are Y26 and Y36.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
21V398000
Potential Number of Units Affected:
447985
ELECTRICAL SYSTEM
Mar 11, 2021
A vehicle fire increases the risk of injury.
Summary:
Chrysler (FCA US, LLC) is recalling certain 2021 Ram 2500, 3500, and 3500, 4500, and 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the Solid State Intake Heater Grid Relay, which could result in a vehicle fire.
What should you do:
Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Customers are advised to not park these vehicles inside of buildings or structures, or near other vehicles until the vehicle has the final repair completed. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Y08. This recall has been superseded by recall number 21V-798.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA CAMPAIGN ID Number:
21V163000
Potential Number of Units Affected:
19214
Check Vehicle for Unrepaired Recalls
Enter a valid 17-character VIN
Enter a valid 17-character VIN
"Multiple issues with this system - very costly to repair"
Anonymous, SD (2021 Ram 3500 Laramie 6.7-L 6 Cyl diesel)